Feb 27, 2013
Laura

Recipe: Potato and Pork Sausage

Potato Sausage RecipeThere’s been a little pause in the blog…mostly because I had a little excitement: I co-hosted the Italian morning radio show Amici on CHIN Radio here in Toronto yesterday! More about that tomorrow…but first we need to get to a recipe! The last recipe of All Food February is a big one. Firstly, it’s about sausages, which is a request I get a lot. But secondly, it’s for a sausage recipe I can’t find anywhere else. Have you ever made potato and pork sausages?

This recipe comes from my husband’s family. He fondly remembers eating these as a kid on family road trips. They would pack the sausages, straight from the freezer, into tin foil and place them in the back windshield of the car to warm up in the summer sun as they drove to their destination. The recipe itself is typical of southern Italian cooking, and Italian austerity measures, as it uses potatoes as a filler for meat (which there wasn’t a lot of years ago).

Last year my husband decided he wanted to make these sausage that he hadn’t had in years and we searched desperately for a recipe. We found nothing: not on food recipe sites, not in books, not even on blogs. I started to doubt that it was possible to even make these sausages (wouldn’t the potato go bad?) and only came around when I was watching an episode of Lidia’s Italy and she was mentioning different types of sausages found in Italy. Potato and pork were mentioned – so they do exist! Too bad she didn’t give a recipe for them! We ended up inviting over the Nonni and got to work putting this old recipe back together and making some mighty fine dried sausages.

The recipe is approximate, you’ll need to gauge your needs based on the amount of pork you use and the flavours you want. As always, before you dive into recipes that preserve meat be sure to read up on proper meat handling and curing techniques.

Potato & Pork Sausage
1 pork shoulder, ground
Equal part boiled potatoes (Yukon Gold preferred)
1 liter of red pepper sauce
2 handfuls of salt
1/2 a handful of fennel
2 tablespoons dried hot pepper flakes

Potato & Pork Sausage Recipe

 

 

 

 

 

 

 

 

 

 

 

You can purchase a pork shoulder at a butcher and ask them to process it for you into ground meat. Or debone your pork shoulder, cutting it into large pieces and leaving some fat with the meat. Process it through a meat grinder. You’ll also need to purchase natural sausage casings from a butcher (or, if you prefer, you can get the synthetic kind.) The casings need to be cleaned by running cold water through them and turning them inside out. Turn them right side out again and let them sit in lemon water over night. Peel your potatoes and boil them in a large pot of water, removing them when they are tender. Let the potatoes cool fully.

Potato & Pork Sausage Recipe

 

 

 

 

 

 

 

 

 

 

 

Once your meat, potatoes and casings are prepared, you can begin the sausage making process. Crumble the potatoes by hand into 1/2 inch pieces. Mix the ground pork into the potatoes. Add in the red pepper sauce, fennel, hot pepper flakes and salt. You can mix this together by hand or, if you have one large enough, a stand mixer. Allow the meat mixture to rest for 2 to 3 hours in cool place so that the potato absorbs the flavours you’ve added in.

Potato & Pork Sausage Recipe
Once the meat is ready, you get to eat! Take a handful or so of the mixture and cook, with a tablespoon of oil, in a frying pan until the meat is cooked through and crispy. This taste test will let you know if you’ve got the proper ratios of flavours for your sausage. You’ll want to be the most concerned with the amount of salt (as this is required to cure the meat) and the spiciness. The meat should taste a little salty and the heat should be to your liking. Adjust the seasoning in the meat accordingly to your taste test.

Potato & Pork Sausage Recipe

 

 

 

 

 

 

 

 

 

 

 

When you are happy with your meat mixture, it’s time to make the sausages. For this you’ll need a sausage stuffer, butcher’s twine for tieing, scissors and lots of help on hand. Slip a casing onto the stuffing tube, gathering it on the tube and tying off the end. Put the meat into the stuffer and start cranking the meat into the casings. When the meat starts to come out, use one hand to regulate how fast the casing slips off the tube and how tightly packed the meat is in the casing.

Potato & Pork Sausage Recipe

 

 

 

 

 

 

 

 

 

 

 

Tie off links using the twine at 5 to 6 inches long. It’s important to either tightly pack the meat into the casings so that no air is caught inside and harms the curing process or, if you find air bubbles in your finished sausages, prick the casings with a sterilized needle to release the air.

Potato & Pork Sausage Recipe

 

 

 

 

 

 

 

 

 

 

 

Let the sausages rest for a few hours. The sausages then need to be hung up to dry. In links of two or three, hang them in a cool, dry place (a cantina or garage will do) so that they are not touching each other. They need to hang for approximately three weeks until they are cured: they should be hard, but still have some give when you press them with your fingers. Be sure to check on them periodically to ensure they are drying well and no mould is forming on them. These sausages can be vaccum sealed and kept in the freezer or fridge for up to a year.

Potato Sausage RecipeThese are best with bread and cheese, warmed up slightly or even roasted in the oven. Don’t forget to remove the casing before biting in!

Potato Sausage Recipe

Print Friendly

12 Comments

  • My oh my that looks tasty! Yet another item in your “barter” arsenal you can use to secure some homemade bacon! I would also think (and this is an offer) that putting them through the smoker could also add an element of flavour that could enhance this sausage!! Let me know and we’ll pack the smoker up and bring it on over!!

    • Oh now you are thinking! Next time we make up a batch of these, we’ll give you a call!

  • Awesome!!!! Awesome recipe!!! Great blog post!!! This is the vest thursday ever! When do you say we are sharing one of this?

    • Thanks. Eleven exclamation points – I think that’s my best review yet. We can make a trade maybe? For that pistachio spread you guys carry?? :)

  • Those look delicious!!! When you say equal parts of of potatoes, do you mean by weight (pounds) or by volume (cups)? By the way, I love your blog. Reminds me of my childhood.

    • By weight. So if the meat from your pork shoulder weighs 10 pounds, you’ll need 10 pounds of potatoes. Hope that helps and glad you love the blog!

  • These look sooooo good. I just the other day bought two pork shoulder roasts and ground one up for ground pork, and just this morning took the other one out of the freezer for dinner. I love sausages….but they always seem so doubious for content for me. I’m going to have to make some one of these days. And these look like a good place to start.
    I don’t know if I can bring myself to use the real casings though. Have you used the sythetic casing…or the real ones?

  • Where can I get a recipe for the litre of red pepper sauce? Is the salt listed regular table salt or prague salt #2 because the sausage isn’t cooked? I love the recipe and the pictures are great! I just need the red sausage recipe and salt to make them!

    • That’s a tough question – I don’t have a recipe per se, we process bushels of peppers in the summer (boil, crush, boil, jar) but I should take the time to write down the “how to.” Until then, try searching the internet for “red pepper” or “sweet pepper” puree or sauce. This is a typical calabrese addition to sausage.

  • These look absolutely divine! I am definitely going to try them – might add some smokey paprika :)

    • Hi Maureen – what a great idea for an addition. Let me know how it goes!

  • What kind of salt? Pink? Prague Powder #2? Kosher? Iodized Table? Canning? Rock? Sea? I want to try this recipe, but need to know what kind before making it…

Leave a comment

Tomato-growing, family-surrounded, big life and big laughs girl sorting out an Italian-Canadian life. Recipes are from the heart and the family vault. Learn more about this blog...

Sign up for updates from An Italian-Canada Life blog

Connect with me

Link to my Facebook Page
Recommend this page!
Link to my Pinterest Page
Link to my Rss Page
Link to my Twitter Page

My Instagr.am Gallery


Follow me on Twitter

Search the blog

© Laura D'Amelio and An Italian-Canadian Life, 2013. Unauthorized use and/or duplication of this material without express and written permission from this blog’s author and/or owner is strictly prohibited. Excerpts and links may be used, provided that full and clear credit is given to Laura D'Amelio and An Italian-Canadian Life with appropriate and specific direction to the original content. For permissions, please fill in the form on the contact page.